littleloris's 1989 Honda VFR 400
Info: Broken lug from bike falling off the stand.
Views / Day: 0.1
3040x2288 / 979 KB

 		 Info: Another broken lug. The inside of the fairing has had repairs before from previous owners, so it's withstood worse. The straw that broke the donkey's back? There's more...
Views / Day: 0.1
3040x2288 / 966 KB

 		 Info: RH rear set snapped off at all 3 fixings. Initially, I thought it was just a new heel plate needed, but on closer inspection, the brake pedal also had cracked. You can see it on the far left of the pi...
Views / Day: 0.1
3040x2288 / 1,063 KB

 		 Info: Scratched rear seat cowl. Some of this could polish out but the rest is deep into the plastic.
Views / Day: 0.1
3040x2288 / 982 KB

 
Info: Seeing as there's damage to the right hand side of the bike, I'm taking the opportunity to fit my Tyga Performance full exhaust system. I can give it a good clean at the same time.
Views / Day: 0.1
3040x2288 / 972 KB

 		 Info: Exhaust wasn't in the best of condition. I knew to expect some rust! The clips had to be prized off with a flat head screwdriver. When I was loosening them the rust gave way to the clamps and they sli...
Views / Day: 0.1
3040x2288 / 954 KB

 		 Info: Upper pipes aren't too bad, but the lowers are a little worse for wear. This is the left hand side. Same happened to the clamp. Amazingly, they weren't broken and were easy to slip up the pipe, despit...
Views / Day: 0.1
3040x2288 / 916 KB

 		 Info: Exhaust system finally came away. The lowers and silencer weighed, in total, about 3 or 4 kgs. When the pipes came away from the ports I loosened the exhaust hanger and off it came.
Views / Day: 0.1
3040x2288 / 984 KB

 
Info: Link pipes showing a bit of rust. If scrubbed back and polished up the pipes cuold look really good.
Views / Day: 0.1
3040x2288 / 938 KB

 		 Info: Gasket removal for front headers. Initially, I couldn't see them and as this was my first shot at changing an exhaust I didn't even know they were there! After some research I gave them a scrub with a...
Views / Day: 0.1
3040x2288 / 856 KB

 		 Info: After the removal of the gaskets it's more clear where to put the new ones!
Views / Day: 0.1
3040x2288 / 922 KB

 		 Info: Rear ports with the gaskets still in. Notice the copper-look of the rings.
Views / Day: 0.1
3040x2288 / 951 KB

 
Info: Gaskets now out. Time for a clean and polish!
Views / Day: 0.1
3040x2288 / 985 KB

 		 Info: The weld from the exhaust was so bad and disfigured that it would scratch the swing arm when the suspension wasn't compressed.
Views / Day: 0.1
3040x2288 / 886 KB

 		 Info: Polished up swing arm and heel plate. Camera doesn't really give it justice!
Views / Day: 0.1
3040x2288 / 1,003 KB

 		 Info: Took the annoying flexi-tubing that surrounded the bad welding job from the pipes to the end can. Was held on by a couple of clamps.
Views / Day: 0.1
3040x2288 / 2,597 KB

 
Info: On closer inspection you can see the state of the weld and what the intentions were. I will try, at some stage, to seperate the can from down pipes and get them polished up and re-welded if possible.
Views / Day: 0.1
3040x2288 / 2,258 KB

 		 Info: A naked VFR! There are some parts that could do with re-painting, such as lower radiator and top yoke. So very little time though!
Views / Day: 0.2
3040x2288 / 2,940 KB

 		 Info: Looks much better without the exhaust at all!! Perhaps I should invest in an underseat job..?
Views / Day: 0.1
3040x2288 / 3,039 KB

 		 Info: You can see the paint flaking off the lower rad. With the fairing on you shouldn't be able to see it but it'd be nice to keep it protected.
Views / Day: 0.1
3040x2288 / 2,627 KB

 
Info: New Tyga Performance exhaust connected and ready to go!
Views / Day: 0.1
3040x2288 / 2,666 KB

 		 Info: New gaskets are in...
Views / Day: 0.1
3040x2288 / 2,421 KB

 		 Info: All springs attached and Tyga end can slipped on.
Views / Day: 0.2
3040x2288 / 2,374 KB

 		 Info: Pipes connected to front and rear headers minus the RH side rear set.
Views / Day: 0.1
3040x2288 / 2,276 KB

 
< BACK
Page: <1> [2]
Sort By: Date / Img Width / File Size
NEXT >
Photos: 36
Purchased: Mar 2006
Sold: n/a

Related Links:
Return to littleloris's BikePics Member Page
Return to the BikePics 1989 Honda VFR 400 Page
Return to the BikePics Honda VFR 400 Page
Return to the BikePics Honda Page



©1997-2013 Bikepics PTY LTD